A lot of people come by the project – tourist and locals – and almost everyone says the same thing. “Slowly but surely it’s coming up”. My reply to all of them is the same, “It sure doesn’t seem slow to me!” We’ve been at it now for a little over 5 months and it seems like time has flown by.
After we finished the 3rd floor cast, we didn’t slow down a bit. The next day blocks were being hoisted to the top to begin the railing around the rooftop entertainment area, which is about 1,000 sq ft. While the carpenters start from one end with the roof peak, another crew starts forming the parapet wall “cantilever” that will surround the entire rooftop. It will become the floor of the box-gutter and will also be the base for the parapet wall.
This enclosed gutter system and parapet wall are important for a couple of reasons. First, this wall will be higher than the finished roof. This is a Miami-Dade County hurricane spec that will “in theory” allow a hurricane to pass over the top of the roof without being able to peel up an edge and lift the roof. Second, it will enclose the gutter system so there won’t be any impedance to water going to the cistern. Finally, it is a heck of a lot nicer looking from the ground when there are no exterior gutters.
The Covintec goes in quickly and the guys get the roof peak set.
(No “slowly but surely” at this job-site!!!)
A crew starts setting the roof rafters while the guys start hoisting blocks to the rooftop. A crew starts setting blocks on the West side of the rooftop so that the roof-peak can be attached and locked in. Within two days, the rooftop block is set, the roof locked in and 80% of the rafters have been set. Seem slow and sure to you???
When all rafters are set, the crew goes back and ties everything in with hurricane straps. Nothing beats cheap insurance, right! We may have gone a little overboard with the straps – using double or triple the amount called for. But every rafter is strapped in place and is firmly anchored to the sill plates, which are set in the concrete and tied in to the beams using stainless steel threaded rods. I can’t see how this roof is going ANYWHERE, but I’ve also never seen a Category 5 Hurricane. Hopefully I never will!
While this is happening, the plaster crew has finished the first floor (right on schedule) and joined our crew on the rooftop to start the arduous task of plastering the Covintec and finishing the box-gutters.
Keep in mind that every thing is now coming to the rooftop via a hoist, rope and pulley. This means EVERY block, ALL cement (94-lb bags), sand, gravel and water (via 5-gallon buckets!) The “crane” is going non-stop all day!
A crew forms up for the rooftop columns that tie the block together, then start forming the 14-inch counter-top that will cap the rooftop railing and surround the entire entertainment area. This rooftop is really becoming the center of attention as the guys are picturing themselves standing at the bar, “I’ll take a Margarita, por favor!”
Juan Diaz comes up and shares the excitement. As always, he has a few suggestions. This has become a typical conversation: “Mr. Mike, we have gas right over here that we can run over there so you can put in a rooftop BBQ grill”. Me, “perfect, that’ll save me from running up and down the stairs”. Juan, “wouldn’t it be nice to have some lights under this counter and an outlet hidden here for some Christmas lights?” Me, “I was thinking the same thing, Juan”. Him, “if you want, I can run cable up here so you could put a TV to watch football?” He means soccer, but I’m thinking “Ohio State Football, baby”…”great idea, Juan!” OK OK, you can stop asking now!!!
On a tangent: A friend of mine, Rob (of Day Dreamin’ Belize), who is largely responsible for hooking me up with Omar from the beginning, invited Omar, Juan Diaz and I to go to the Canada vs Belize World Cup qualifier in the capital city – Belmopan. Juan and Omar have been playing football together since they were little. Juan arranged the tickets and hotel, and we all flew in like VIP’s on Rob’s Twin Engine rocket ship for the game!!! Belize eliminated in the 1-1 tie, but WOW, what an AWESOME experience!!!
As the roof framing continues, Erwin is back at it again, working on the 2nd spiral stairway that will connect the 2nd floor veranda to the rooftop. This is a long process that takes shape over 2-1/2 weeks. Erwin usually works alone, but Omar assigns a helper to move it along. It’s a detailed task that takes a lot of math, measuring, cutting nailing. It looks like it’s going to be a spectacular addition – a mirror image of the one below it!
While the plastering is going on, and in a blink of an eye, the rafters are set and the roofing material (specially coated zinc) starts to go in. The first few sheets seem to take forever, but have to be right in order for the roof to come out. There’s a little head-scratching and a lot of Spanish (a few new words added to the vocabulary!). But three days later we had this:
Slowly but surely??? Anything but!!
Also while this is going on upstairs, Juan and his sons are busy at work downstairs, finishing the rough electrical, cable, internet and plumbing.
When the rooftop is finished, the plaster crew starts the exterior of the building, beginning with the north side of the building, then progressing to the east side (seafront). They have added 4 additional guys (now up to 8) and have also begun leveling the first floor. This is important as we are now all set for TILE!!!
Hard to believe that they will be setting tile next week, but we are currently 16 days ahead of schedule. The roof is on the schedule to be completed by October 1 and it is DONE on September 14th!
Acknowledging things aren’t always perfect, we need to talk about Mahogany. We ordered 4,000 board feet of Mahogany for doors and cabinets for the project. It should have gone to the kiln, been dried and delivered by the end of August. Small glitch. The salesman, Gustavo, starts playing games with the order and evidently failing to tell the truth when asked direct questions. It cost me two trips to the mainland, including one overnight stay.
I traveled from San Pedro, to Belize City, to Orange Walk, back to Belize City, then to San Pedro to look at wood I thought we bought, but later found out, we DIDN’T. The second trip was San Pedro, Belize City, Orange Walk, then to Little Belize, (which I think it’s safe to say is in the middle of no where, just past the outskirts and up the road from the middle of NO WHERE!), back to Belize City. The next day we went Belize City to Spanish Lookout and then back to San Pedro. At this moment in time, I still do not have any Mahogany.
This is causing a lot of heartburn since we are resolved to keep our deadlines. We have been discussing hiring a second and maybe third cabinet-maker so that we can spread the doors and cabinets out in order to meet our deadline. Needless to say, GUSTAVO and I are not on the best of terms. Fortunately it was half up front and half on delivery, so we’ll see how that half on delivery part goes.
On a positive note, because of this experience, I have become a Mahogany professional and have seen parts of Belize that I never would have otherwise. I spent a lot of time on dirt roads, crossed a river on a hand-cranked ferry for the fee of “any donation is good”, and met some very nice and honest Mennonites in Little Belize and Spanish Lookout who tell it like it is (much appreciated).
Special thanks to another friend of mine, Brian “Mac” McCarron for coming along on “Mac ‘n Mikes Big (Belize) Adventure”!!
Well, it is Independence day here in Belize – September 21. 1981 I believe, so we have a much-needed day off! We cast the 2nd spiral staircase on Saturday so you’ll have to come back soon to see some more great pictures.
As always, thanks for reading and sharing in our tropical building adventure. We hope to start taking some pre-bookings (contingent upon our being open!) for January 1st 2016. So if you’re thinking you might want to bet on us being done on schedule, stay tuned to TwistedPalmVillas.com. Thanks again for liking us and following us. Keep the questions, comments and support coming!!!